Bora Variant


VW Golf  Camshaft Adjuster, Checking Function

VW Golf Camshaft Adjuster, Checking Function

Camshaft Adjuster, Checking Function The instruction is suitable for the following models: Golf,Bora Variant,Golf,Jetta (Mexiko) Test Conditions Coolant temperature must be at least 85 °C (185 °F), see Display group 04, display field 3 Test Sequence Connect the Vehicle Diagnostic Tester and select the control module for engine electronics with the “address word 01”. Engine must run at idle for this. Connect the scan tool and select the engine control module. Refer to Fuel Injection and Ig..

VW Golf  Check Activation

VW Golf Check Activation

Check Activation The instruction is suitable for the following models: Golf,Bora Variant,Golf,Jetta (Mexiko) Check the activation of the camshaft adjustment solenoid valve via the output Diagnostic Test Mode (DTM). If control is OK:..

VW Golf  Checking for Leaks

VW Golf Checking for Leaks

Checking for Leaks The instruction is suitable for the following models: Golf,Bora Variant,Golf,Jetta (Mexiko) If a small or large leak was recognized during the Evaporative Emission (EVAP) canister system function test, proceed as follows. Switch off the ignition. Check whether the fuel filler cap is completely closed or whether the seal leaks, replace if necessary. Repeat function test. If malfunction persists: Fold the rear bench seat forward. Remove cover under the bench seat. Check ..

VW Golf  Delivery Quantity, Checking

VW Golf Delivery Quantity, Checking

Delivery Quantity, Checking The instruction is suitable for the following models: Golf,Bora Variant,Golf,Jetta (Mexiko) Test Conditions Voltage supply OK. The Injection Rate Comparison Meter Kit - Remote Cable VAG1348/3A is connected. Test Sequence Remove the fuel cap from the fuel filler tube. WARNING The fuel supply line is under pressure. Always wear protective eyewear and protective clothing to prevent injuries and contact with skin. Place a cloth on the connection location before..

VW Golf  Diagnostic Pump, Checking Electrically

VW Golf Diagnostic Pump, Checking Electrically

Diagnostic Pump, Checking Electrically The instruction is suitable for the following models: Golf,Bora Variant,Golf,Jetta (Mexiko) Remove the right rear wheel housing liner. Refer to Body Exterior Rep. Gr. 66 Description and Operation . Remove the 3-pin connector Leak Detection Pump V144 . Connect the Analog/Digital Multimeter FLU83III for resistance measurement between terminals 1 and 3 on Leak Detection Pump V144 . Specified value: 640 to 720 Ω. Connect the Analo..

VW Golf  Exhaust Valve Seat, Reworking

VW Golf Exhaust Valve Seat, Reworking

Exhaust Valve Seat, Reworking The instruction is suitable for the following models: Golf,Bora Variant,Golf,Jetta (Mexiko) Dimension Intake Valve Seat Diameter a mm 29.0 b mm Maximum permitted reworking dimension. Refer to Note . c mm Approximately 1.8 Z Cylinder Head Lower Edge α 45° Valve Seat Angle β 30° Upper Correction Angle γ 60° Lower Correction Angle How to calculate maximum permissible reworking dimension Go to article...

VW Golf  Fuel Pump Check Valve, Checking

VW Golf Fuel Pump Check Valve, Checking

Fuel Pump Check Valve, Checking The instruction is suitable for the following models: Golf,Bora Variant,Golf,Jetta (Mexiko) Test Conditions The Injection Rate Comparison Meter Kit - Remote Cable VAG1348/3A is connected. The Fuel Injection Gauge Kit VAG1318 is still connected. Test Sequence Note This test also checks the connections of the fuel supply line from fuel delivery unit to connection point of Fuel Injection Gauge Kit VAG1318 for leaks. Close the shut-off valve on..

VW Golf  Function and Power Supply, Checking

VW Golf Function and Power Supply, Checking

Function and Power Supply, Checking The instruction is suitable for the following models: Golf,Bora Variant,Golf,Jetta (Mexiko) Note In the continuing work procedure, it is lisibly necessary to disconnect the battery Ground (GND) cable. Check whether a coded radio is installed. If so, obtain anti-theft coding beforehand. Remove the cover from fuel delivery unit. Briefly operate the starter. Fuel Pump (FP) must run audibly. Turn off the ignition. If fuel pump does not activate: Remove ..

VW Golf  Function Test

VW Golf Function Test

Function Test The instruction is suitable for the following models: Golf,Bora Variant,Golf,Jetta (Mexiko) Connect the Vehicle Diagnostic Tester and select the control module for engine electronics with the “address word 01”. Engine must run at idle for this. Connect the scan tool and select the engine control module. Refer to Fuel Injection and Ignition Rep. Gr. 01 Diagnosis and Testing . Scan tool display:Quick data transfer HELPSelect function XX Press the buttons 0 and 8 for t..

VW Golf  Indicator Lamp, Function Test

VW Golf Indicator Lamp, Function Test

Indicator Lamp, Function Test The instruction is suitable for the following models: Golf,Bora Variant,Golf,Jetta (Mexiko) Refer to Rep. Gr. 01 ...




Showing 1 to 10 of 63 (7 Pages)